东莞荣誉电子有限公司
主营：贴片电解电容,SMD电解电容,片式电解电容,牛角电解电容,螺栓电解电容,固态电容
主营：贴片电解电容,SMD电解电容,片式电解电容,牛角电解电容,螺栓电解电容,固态电容
所在地:
广东 东莞
产品价格:
面议/PCS(大量采购价格面议)
最小起订:
500
发布时间:
2022-04-24
有效期至:
2022-05-24
产品详细
贴片铝电解电容规格 贴片电解电容尺寸
0.47uF50v|50v 0.47uF 4*5.4 0.47uF63v|63v0.47uF 4*5.4 0.47 uF 100v|100v0.47uF 4*5.4
1uF50v|50v1uF 4*5.4 1uF63v|63v1uF 4*5.4 1uF 100v|100v1uF 6.3*5.4
2.2uF50v|50v 2.2uF 4*5.4 2.2uF63v|63v1uF 4*5.4 2.2 uF 100v|100v2.2uF 6.3*5.4
3.3uF35v|35v3.3uF 4*5.4 3.3uF50v|50v3.3uF 4*5.4 3.3uF63v|63v3.3uF 5*5.4
3.3uF100v|100v3.3uF 6.3*5.4
4.7uF25v|25v4.7uF 4*5.4 4.7uF35v|35v4.7uF 4*5.4 4.7uF50v|50v4.7uF 5*5.4 4.7uF63v|63v4.7uF 6.3*5.4 4.7uF100v|100v4.7uF 6.3*7.7
6.8uF25v|25v6.8uF 4*5.4 6.8uF35v|35v6.8uF 4*5.4 6.8uF50v|50v6.8uF 5*5.4 6.8uF63v|63v6.8uF 6.3*5.4 6.8uF100v|100v6.8uF 6.3*7.7
8.2uF25v|25v8.2uF 4*5.4 8.2uF35v|35v8.2uF 4*5.4 8.2uF50v|50v8.2uF 5*5.4 8.2uF63v|63v8.2uF 6.3*5.4 8.2uF100v|100v8.2uF 6.3*7.7
10uF16v|16v10uF 4*5.4 10uF25v|25v10uF 4*5.4 10uF35v|35v10uF 4*5.4 10uF50v|50v10uF 6.3*5.4 10uF63v|63v10uF 6.3*5.4 10uF100v|100v10uF 6.3*7.7
22uF6.3v|6.3v22uF 4*5.4 22uF10v|10v22uF 4*5.4 22uF16v|16v22uF 4*5.4 22uF25v|25v22uF 5*5.4 22uF35v|35v22uF 6.3*5.4 22uF50v|50v22uF 6.3*5.4 22uF63v|63v22uF 6.3*7.7 22uF220v|220v22uF 8*10.2
33uF6.3v|6.3v33uF 4*5.4 33uF10v|10v33uF 4*5.4 33uF16v|16v33uF 5*5.4 33uF25v|25v33uF 5*5.4 33uF35v|35v33uF 6.3*5.4 33uF50v|50v33uF 6.3*7.7 33uF63v|63v33uF 8*10.2 33uF330v|330v33uF 10*10.2
47uF6.3v|6.3v47uF 4*5.4 47uF10v|10v47uF 5*5.4 47uF16v|16v47uF 5*5.4 47uF25v|25v47uF 6.3*5.4 47uF35v|35v47uF 6.3*5.4 47uF50v|50v47uF 6.3*7.7 47uF63v|63v47uF 8*10.2 47uF470v|470v47uF 10*10.2
68uF6.3v|6.3v68uF 5*5.4 68uF10v|10v68uF 6.3*5.4 68uF16v|16v68uF 6.3*5.4 68uF25v|25v68uF 8*6.5 68uF35v|35v68uF 8*6.5 68uF50v|50v68uF 8*10.2 68uF63v|63v68uF 10*10.2 68uF680v|680v68uF 10*10.2
82uF6.3v|6.3v82uF 5*5.4 82uF10v|10v82uF 6.3*5.4 82uF16v|16v82uF 6.3*5.4 82uF25v|25v82uF 8*6.5 82uF35v|35v82uF 8*6.5 82uF50v|50v82uF 8*10.2 82uF63v|63v82uF 10*10.2 82uF820v|820v82uF 10*10.2
100uF6.3v|6.3v100uF 5*5.4 100uF10v|10v100uF 6.3*5.4 100uF16v|16v100uF 6.3*5.4 100uF25v|25v100uF 6.3*7.7 100uF35v|35v100uF 6.3*7.7 100uF50v|50v100uF 8*10.2 100uF63v|63v100uF 10*10.2
150uF6.3v|6.3v150uF 6.3*5.4 150uF10v|10v150uF 6.3*5.4 150uF16v|16v150uF 6.3*7.7 1220uF6.3v|6.3v220uF 6.3*5.4 220uF10v|10v220uF 6.3*7.7 220uF16v|16v220uF 6.3*7.7 220uF25v|25v220uF 8*10.2 220uF35v|35v220uF 8*10.2 220uF50v|50v220uF 10*10.2
50uF25v|25v150uF 8*10.2 150uF35v|35v150uF 8*10.2 150uF50v|50v150uF 10*10.2
330uF6.3v|6.3v330uF 6.3*7.7 330uF10v|10v330uF 8*10.2 330uF16v|16v330uF 8*10.2 330uF25v|25v330uF 10*10.2 330uF35v|35v330uF 10*10.2
470uF6.3v|6.3v470uF 6.3*7.7 470uF10v|10v470uF 8*10.2 470uF16v|16v470uF 8*10.2 470uF25v|25v470uF 10*10.2
680uF6.3v|6.3v680uF 8*10.2 680uF10v|10v680uF 10*10.2 680uF16v|16v680uF 10*10.2
820uF6.3v|6.3v820uF 8*10.2 820uF10v|10v820uF 10*10.2 820uF16v|16v820uF 10*10.2
1000uF6.3v|6.3v1000uF 8*10.2 1000uF10v|10v1000uF 10*10.2 1000uF16v|16v1000uF 10*10.2
贴片铝电解电容规格
产品规格书Product Specification 一、概述 SCOPE 本产品规格书适用于荣誉电子有限公司v-chip型片式铝电解电容器产品。 二、外形图及尺寸表 Case size table
单位:mm
|
|
4 × 5.4 |
5 × 5.4 |
6.3 × 5.4 |
6.3 × 7.7 |
8× 10.5 |
10 × 10.5 |
|
A |
1.8 |
2.1 |
2.4 |
2.4 |
2.9 |
3.2 |
|
B |
4.3 |
5.3 |
6.6 |
6.6 |
8.3 |
10.3 |
|
C |
4.3 |
5.3 |
6.6 |
6.6 |
8.3 |
10.3 |
|
E |
1.0 |
1.3 |
2.2 |
2.2 |
3.1 |
4.5 |
|
L |
5.4 |
5.4 |
5.4 |
7.7 |
10 |
10 |
|
H |
0.5 ~ 0.8 |
0.8 ~ 1.1 |
||||
三、技术性能 Specifications
|
项目Items |
特性 Characteristics |
|||||||
|
工作温度范围 Operating Temperature Range |
-55℃ ~+105℃ |
|||||||
|
额定电压范围 Rated Voltage Range |
6.3V ~ 50V |
|||||||
|
标称电容量范围 Nominal Capacitance Range |
1 ~1000μF |
|||||||
|
标称电容量允许偏差 Nominal Capacitance Tolerance |
±20%（20℃，120Hz） |
|||||||
|
漏电流 Leakage Current |
I≤0.01CRVR or 3(μA)，取非常大者（施加额定电压2分钟） CR：标称电容量（μF） UR：额定电压（V） I≤0.01CRVR or 3(μA) Whichever is greater(After 2 minutes’ application of rated voltage CR: Nominal Capacitance (μF) UR: Rated voltages (V) |
|||||||
|
损耗角正切（tgδ） Dissipation Factor (Max) 20℃, 120Hz |
UR (V) |
6.3 |
10 |
16 |
25 |
35 |
50 |
|
|
tgδ |
0.22 |
0.19 |
0.16 |
0.14 |
0.12 |
0.10 |
||
|
耐久性 Load Life |
+105℃施加额定电压1000小时后，电容器应满足以下要求： After 1000 hours’ application of rated voltage at 105℃, the capacitor shall meet the following requirement: |
|||||||
|
电容量变化率 Capacitance Change |
±20%初始值以内（≤16V：±25%初始值以内） Within ±20% of the initial value(≤16V: within ±25% of the initial value) |
|||||||
|
损耗角正切 Dissipation Factor |
≤ 300%初始规定值 Not more than 300% of the initial specified value |
|||||||
|
漏电流 Leakage Current |
≤ 初始规定值
1 |
|||||||
产品规格书Product Specification
四、试验方法及要求 Tests
|
高温贮存 Shelf Life |
+105℃ 贮存1000小时后，加额定工作电压30分钟,电容器应满足以上耐久性要求 After storage for 1000 hours at +105℃, UR to be applied for 30 minutes ,the capacitors shall meet the requirement of load life above |
|||||||
|
低温特性 Low Temperature Stability 阻抗比 Impedance Ratio (120Hz) |
UR (V) |
6.3 |
10 |
16 |
25 |
35 |
50 |
|
|
Z(-25℃)/Z(+20℃) |
2 |
2 |
2 |
2 |
2 |
2 |
||
|
Z(-40℃)/Z(+20℃) |
4 |
4 |
3 |
3 |
3 |
3 |
||
|
耐焊接热 Resistance to Soldering Heat |
在260℃的条件下，电容器在热板上保持10秒，然后从热板上取出电容器，让其在室温下恢复，电容器应满足以下要求：The capacitors shall be kept on the hot plate maintained at 260℃ for 10 seconds. After removing from the hot plate and restored at room temperature, they meet the following requirement. |
|||||||
|
电容量变化率 Capacitance Change |
±10%初始值以内 Within ±10% of the initial value |
|||||||
|
损耗角正切（tgδ） Dissipation Factor |
≤初始规定值 Not more than the initial specified value |
|||||||
|
漏电流 Leakage Current |
≤ 初始规定值 Not more than the initial specified value |
|||||||
五、标称电容量、额定电压、额定纹波电流与外形尺寸对应表
Nominal capacitance, rated voltage, rated ripple current and case size table
|
V |
6.3 |
10 |
16 |
25 |
35 |
50 |
||||||||||||
|
μF |
D×L mm |
Impedance Ω |
I~ mA |
D×L mm |
Impedance Ω |
I~ mA |
D×L mm |
Impedance Ω |
I~ mA |
D×L mm |
Impedance Ω |
I~ mA |
D×L mm |
Impedance Ω |
I~ mA |
D×L mm |
Impedance Ω |
I~ mA |
|
1.0 |
|
|
|
|
|
|
|
|
|
|
|
|
4×5.4 |
5.0 |
50 |
4×5.4 |
5.0 |
50 |
|
1.5 |
|
|
|
|
|
|
|
|
|
|
|
|
4×5.4 |
5.0 |
50 |
4×5.4 |
5.0 |
50 |
|
2.2 |
|
|
|
|
|
|
|
|
|
|
|
|
4×5.4 |
5.0 |
50 |
4×5.4 |
5.0 |
50 |
|
3.3 |
|
|
|
|
|
|
|
|
|
|
|
|
4×5.4 |
5.0 |
50 |
4×5.4 |
5.0 |
50 |
|
4.7 |
|
|
|
|
|
|
|
|
|
4×5.4 |
5.0 |
50 |
4×5.4 |
5.0 |
50 |
5×5.4 |
2.6 |
80 |
|
6.8 |
|
|
|
|
|
|
|
|
|
4×5.4 |
5.0 |
50 |
5×5.4 |
2.6 |
80 |
6.3×5.4 |
1.3 |
115 |
|
10 |
|
|
|
|
|
|
4×5.4 |
5.0 |
50 |
5×5.4 |
2.6 |
80 |
5×5.4 |
2.6 |
80 |
6.3×5.4 |
1.3 |
115 |
|
15 |
|
|
|
|
|
|
5×5.4 |
2.6 |
80 |
6.3×5.4 |
1.3 |
115 |
6.3×5.4 |
1.3 |
115 |
6.3×5.4 |
1.3 |
115 |
|
22 |
4×5.4 |
5.0 |
50 |
5×5.4 |
2.6 |
80 |
5×5.4 |
2.6 |
80 |
6.3×5.4 |
1.3 |
115 |
6.3×5.4 |
1.3 |
115 |
6.3×7.7 |
0.8 |
150 |
|
33 |
5×5.4 |
2.6 |
80 |
5×5.4 |
2.6 |
80 |
6.3×5.4 |
1.3 |
115 |
6.3×5.4 |
1.3 |
115 |
6.3×7.7 |
0.8 |
150 |
6.3×7.7 |
0.8 |
150 |
|
47 |
5×5.4 |
2.6 |
80 |
6.3×5.4 |
1.3 |
115 |
6.3×5.4 |
1.3 |
115 |
6.3×7.7 |
0.8 |
150 |
6.3×7.7 |
0.8 |
150 |
8×10.5 |
0.5 |
220 |
|
68 |
6.3×5.4 |
1.3 |
115 |
6.3×5.4 |
1.3 |
115 |
6.3×7.7 |
0.8 |
150 |
6.3×7.7 |
0.8 |
150 |
6.3×7.7 |
0.8 |
150 |
8×10.5 |
0.5 |
220 |
|
100 |
6.3×5.4 |
1.3 |
115 |
6.3×7.7 |
0.8 |
150 |
6.3×7.7 |
0.8 |
150 |
6.3×7.7 |
0.8 |
220 |
8×10.5 |
0.5 |
220 |
8×10.5 |
0.5 |
220 |
|
150 |
6.3×7.7 |
0.8 |
150 |
6.3×7.7 |
0.8 |
150 |
6.3×7.7 |
0.8 |
150 |
8×10.5 |
0.5 |
220 |
8×10.5 |
0.5 |
220 |
10×10.5 |
0.3 |
330 |
|
220 |
6.3×7.7 |
0.8 |
150 |
6.3×7.7 |
0.8 |
150 |
8×10.5 |
0.5 |
220 |
8×10.5 |
0.5 |
220 |
10×10.5 |
0.3 |
330 |
10×10.5 |
0.3 |
330 |
|
330 |
6.3×7.7 |
0.8 |
150 |
8×10.5 |
0.5 |
220 |
10×10.5 |
0.3 |
330 |
10×10.5 |
0.3 |
330 |
10×10.5 |
0.3 |
330 |
|
|
|
|
470 |
8×10.5 |
0.5 |
220 |
8×10.5 |
0.5 |
220 |
10×10.5 |
0.3 |
330 |
10×10.5 |
0.3 |
330 |
|
|
|
|
|
|
|
680 |
8×10.5 |
0.5 |
220 |
10×10.5 |
0.3 |
330 |
10×10.5 |
0.3 |
330 |
|
|
|
|
|
|
|
|
|
|
1000 |
10×10.5 |
0.3 |
330 |
10×10.5 |
0.3 |
330 |
|
|
|
|
|
|
|
|
|
|
|
|
I~=Rated ripple current (mA) (105℃, 120Hz) I~=额定纹波电流（mA）（105℃，100KHz）
2
Impedance=Impedance(Ω) at 25℃,100kHZ
产品规格书Product Specification
四、构造图及材料表 Frame drawing and materials
|
序号 No. |
部件名称 Parts |
材料名称 Material |
主要供应厂家名称 Main supply Factory |
|
1 |
引出线 |
铝线LG3+镀锡铜钢线 AL- wire LG3+Tin- plating of copper cover steel |
全用电子有限公司 QUANYONG ELECTRONIC CO., LTD. |
|
2 |
橡胶塞 |
丁基橡胶 IIR rubber |
韩国JCC JCC, Co. (KOREA) |
|
3 |
PE铝壳 PE- CASE |
99.5%纯度铝 AL –99.5% |
韩国DNT DNT CO.(KOREA) |
|
4 |
阳较箔AL – foil(+) |
99.99%或99.98%形成铝箔 Formed AL 99.98% or 99.98% |
日本JCC公司 JCC Co. (JAPAN) |
|
5 |
阴较箔AL – foil(-) |
99.7%铝箔 Etched AL 99.7% |
韩国JCC公司 JCC Co. (KOREA) |
|
6 |
电解纸 Separstor paper |
电解电容器纸 Electrolytic Capacitor paper |
日本NKK 公司 NKK Co.(Japan) |
|
7 |
座板BASE |
PPS |
韩国JS公司 JS Co.(KOREA) |
3
产品规格书Product Specification
六、标志 Marking
见外形图及尺寸表
八、片式铝电解电容的编带
V- Chip Type Aluminum Electrolytic Capacitors
n 编带 Carrier tape
|
|
n 编带包装盘 Reel
|
Package quantity 包装数量 ФD Quantity / Reel 数量 / 每盘 4 2000pcs 5、6.3 1000pcs 6.3×7.7 1000pcs 8、10 500pcs （mm） ФD 4 5 6.3 8 10 T 14 14 18 26 26
|
4
￥0.25PCS 元
￥0.25PCS 元